1、有机硅锌粉底漆Intended Uses用途有机硅锌粉底漆是一种灰色漆，用于温度 150 -500（如发动机、锅炉、废弃管道等做底漆）A Grey coating to protection at temperature between 150 and 500, It is suited for motor, boiler and exhaust gas pipeline etc, as primer.ProductDescription产品简介Two packages, Silicone zinc dust paint 双罐装，锌粉有机硅树脂漆Volume Solids 固体份 62.5%D
2、ry Film Thickness 干膜厚度 30-40 microns 30-40 微米Theoretical Coverage 理论涂布率 7.37-9.08 m2/Kg 7.37-9.08 平方米/公斤ProductInformation产品数据 Practical Coverage 实际涂布率 Allow appropriate loss 允许适量损耗Mix Radio 混合比 A : B=100:0.3(WT) 甲:乙=100:0.3(WT)Method of Application 施工方法Airless Spray 无空气喷涂 Recommended 推荐采用Brush or R
3、oller 涂刷或辊涂 Recommended 推荐采用Conventional Spray 传统喷涂 Not Recommended 不推荐采用Thinner 稀释剂 C002Pot Life 使用期 Not limit 不限制Storage 贮存期 Six months 六个月Over coating Interval覆涂间隔Application Details施工详述Drying time 干燥时间SubstrateTemperatureTouch DryHard Dry硬干Mix 最短 Max 最长 底材温度, 表干（h）(h）52335186572242424 h24 h24 h1
4、4 d Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥处 Pack size 包装规格 A;30Kg in 20 liter container 甲:30 公斤装于 20 公升容器中B:90g in a litter bottle 乙:90 克装于一小瓶中Flash Point 闪点 35 Storage andHandling贮存与管理 Specific Gravity 比重 Approx 2.12Kg/L 大约 2.12 公斤/公升Specification and Surface preparation技术要求及表面处理Substr
5、ate should be blasted or rust-removed manually to near whiteClean the surface with cleaner There is no dirt (such as greasy dirt, grease and salts etc) on the surface,The surface to be applied must be clean and dry底材喷砂处理或手工除锈近乎出白用清洁剂清理表面，无污物（如油污、油脂、盐类等）在施工前应保证表面清洁干燥。Limitations限制Recommended coat: Wi
6、th high-pressure airless spray paint, one coat with 30-40 microns of dry film推荐道数：高压无空气喷涂，涂装一道，干膜厚度达 30-40 微米。The product must be used in painting area by professionals. When painting, please be sure to refer to Product Data Sheet and MSDS. Consult our company if consumers could not completely under
7、stand the precautions for safety and health when applying the product.The product is a kind of solvent-based paint. In order to avoid the accident or dangerous occurrence, minimal safety precaution, as follow, should be down.The paint contains volatile solvent and it is flammable, So must keep away
8、from sparks and open flames. No smoking at workplace, Effective precautions (such as using explosion-proof electrical equipments. No static electricity accumulation or SafetyPrecautions安全措施metal collision etc) also should be done so as to avoid product sparks. Enough ventilation is necessary at appl
9、ication sites. In order to remove any danger of explosion, must keep the ratio of gas / air is less than 10 %, Usually 200 m3of ventilation quantity per 1 Kg solvent (according to the solvent) is necessary, it canMaintain the minimum explosive limit. Take effective precautions to prevent skin and ey
10、e contact with the coating (such as the use of overalls, gloves, goggles, face shields and protective oil coating and so on). If paint gets in touch with skin,If accidental skin contact with the product, please use fresh water and soap or an appropriate industrial cleaning agents thoroughly cleansed
11、. In case of eyes being contaminated, rinse with fresh water for 10 min at least and give medical treatment immediately.During painting, it is recommended to wear face shields to prevent inhalation of paint mist and harmful gases.Especially in poorly ventilated environment, it is more necessary.Fina
12、lly, be handled with care so as not to waste paint barrels of pollution of the environment.NOTICE: If consumers have not taken effective safety precautions (Refer to the specification), our company will NOT be responsible for any accident.有机硅锌粉底漆必须由专业人员在工业场所使用。使用时请务必参照本说明书以及相关健康安全手册。若客户在使用本产品前,未能详细了
13、解本产品的相关健康安全知识,请与本公司人员联系。该涂料为溶剂型涂料，为避免事故或危险发生，应采取最低限度的安全措施如下：此涂料为易燃物,并含有挥发性易燃溶剂，故必须远离火星和明火。严禁在作业场所吸烟，并应该采取有效措施，防止火星产生(如采用防爆电器设备，杜绝静电积累,避免金属撞击等)。有机硅锌粉底漆施工场所应尽量保持良好通风。为消除使用过程中的爆炸隐患,应保证足够的通风量以维持气体/空气比例不超过最低爆炸极限的 10 %,通常每千克溶剂需要 200 立方米通风量,(与溶剂种类相关)就能维持最低爆炸极限 10 %的工作环境。 采取有效措施，防止皮肤和眼睛与涂料直接接触(如使用工作服,手套,护目镜,面罩及涂防护油等)。若皮肤不慎与产品相接触,请用清水及肥皂或适当的工业清洁剂彻底清洗；若眼睛受到污染,请即刻用清水冲洗至少 10 分钟,并立即就医。有机硅锌粉底漆施工时，建议佩戴面罩以免吸入漆雾和有害气体，尤其在通风不良的环境下，更要注意。最后请谨慎处理废旧漆桶以免污染环境。责任声明：对于未按本公司所要求采取有效得安全措施而引起的安全事故,本公司不负任何责任。来源 江苏纽克莱涂料有限公司 http:/www.nsk-
