1、环氧富锌车间底漆Intended Uses用途经抛丸或喷砂后的钢材作保养底漆，保养期可达 9-12 可用作镀锌板的防腐涂料，此底漆成膜后防锈性能优异，具有阴极保护作用，杰出的耐热、耐油、耐水性、良好的附着力、在电焊切割时损伤很小，该涂层不影响焊接性能。It is designed for application on grit or shot blasted steel as shop primer with 9-12 months of maintenance period. It may be used as anticorrosive paint on galvanized plate.
2、 This primer forms excellent anticorrosive coating with cathodic protection, good adhesion, outstanding resistance to heat, oil and water etc. Little buring loss is resulted when cutting with electro-welding on the coating which has no effect on welding performance.ProductDescription产品简介双组分,灰色，环氧富锌车
3、间底漆Two packs, Iron red， Epoxy zinc-rich shop primerVolume Solids 固体份 30Dry Film Thickness 干膜厚度20 microns equivalent to 65 microns of wet film20 微米相当于 65 微米湿膜厚Theoretical Coverage 理论涂布率 8 m2 /Kg 8 平方米/公斤ProductInformation产品数据 Practical Coverage 实际涂布率 Allow appropriate loss 允许适量损耗Mix Radio 混合比 A : B=1
4、0:1(WT) 甲:乙=10:1(WT)Method of Application 施工方法Airless Spray 无空气喷涂 Recommended 推荐采用Brush or Roller 涂刷或辊涂 Suitable to repair small area仅适用于小面积维修Conventional Spray 传统喷涂 Not Recommended 不推荐采用Thinner 稀释剂 C006Cleaner 油漆设备清洗剂 COO6Pot Life 使用期 2 5:8h 2 5约 8 小时Application Details施工详述Storage 贮存期 One year 一年Ov
5、er coating Interval覆涂间隔SubstrateTemperature底材温度,Touch Dry表干,hHard Dry硬干, H Mix 最短 Max 最长 Drying time 干燥时间25 0.5 1616 hAbove 10 6 month Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥处 Pack size 包装规格 A;30 Kg in 20 liter container 甲:30 公斤装于 20 公升容器中B:3 Kg in 4liter container 乙:3 公斤装 4 公升容器中Flash P
6、oint 闪点 Paint media:24 甲组份：漆料 24Curing agent:27 乙组份：固化剂 27Storage andHandling贮存与管理Specific Gravity 比重 Approx1.9 Kg/L 大约 1.9 公斤/公升 Specification and Surface preparation技术要求及表面处理Clean all grease according to SSPC-SP1 by solvent cleaningEnsure that the area is clean, dry and free from metallic corrosio
7、n.根据 SSPC-SP1 用溶剂清洗表面去除油脂。保证该区域清洁干燥无金属腐蚀物Limitations限制Recommend coat: Spray one coat with high-pressure airless spray for the purpose of reaching 15-20 microns of dry film thickness.Subsequent coat: Epoxy resin paint, coat-tar epoxy paint, chlorinated rubber paint, alkyd resin paint. Phenolic resin
8、paint, chlorosulphonated polyethylene anticorrosive paint and rlighly chloronated polyethylene anticorrosive paint etc.建议涂装道数：高压无空气喷涂一道，干膜厚度达 15-20后道配套涂料：环氧树脂涂料、环氧沥青涂料、氯化橡胶涂料、醇酸树脂涂料、酚醛树脂涂料、氯磺化聚乙烯防腐涂料、高氯化聚乙烯防腐涂料。SafetyPrecautions安全措施The product must be used in painting area by professionals. When pai
9、nting, please be sure to refer to Product Data Sheet and MSDS. Consult our company if consumers could not completely understand the precautions for safety and health when applying the product.The product is a kind of solvent-based paint. In order to avoid the accident or dangerous occurrence, minima
10、l safety precaution, as follow, should be down.The paint contains volatile solvent and it is flammable, So must keep away from sparks and open flames. No smoking at workplace, Effective precautions (such as using explosion-proof electrical equipments. No static electricity accumulation or metal coll
11、ision etc) also should be done so as to avoid product sparks. Enough ventilation is necessary at application sites. In order to remove any danger of explosion, must keep the ratio of gas / air is less than 10 %, Usually 200 m3of ventilation quantity per 1 Kg solvent (according to the solvent) is nec
12、essary, it canMaintain the minimum explosive limit. Take effective precautions to prevent skin and eye contact with the coating (such as the use of overalls, gloves, goggles, face shields and protective oil coating and so on). If paint gets in touch with skin,If accidental skin contact with the prod
13、uct, please use fresh water and soap or an appropriate industrial cleaning agents thoroughly cleansed. In case of eyes being contaminated, rinse with fresh water for 10 min at least and give medical treatment immediately.During painting, it is recommended to wear face shields to prevent inhalation o
14、f paint mist and harmful gases.Especially in poorly ventilated environment, it is more necessary.Finally, be handled with care so as not to waste paint barrels of pollution of the environment.NOTICE: If consumers have not taken effective safety precautions (Refer to the specification), our company w
15、ill NOT be responsible for any accident.本产品必须由专业人员在工业场所使用。使用时请务必参照本说明书以及相关健康安全手册。若客户在使用本产品前,未能详细了解本产品的相关健康安全知识,请与本公司人员联系。该涂料为溶剂型涂料，为避免事故或危险发生，应采取最低限度的安全措施如下：此涂料为易燃物,并含有挥发性易燃溶剂，故必须远离火星和明火。严禁在作业场所吸烟，并应该采取有效措施，防止火星产生(如采用防爆电器设备，杜绝静电积累,避免金属撞击等)。施工场所应尽量保持良好通风。为消除使用过程中的爆炸隐患,应保证足够的通风量以维持气体/空气比例不超过最低爆炸极限的 10 %,通常每千克溶剂需要 200立方米通风量,(与溶剂种类相关)就能维持最低爆炸极限 10 %的工作环境。 采取有效措施，防止皮肤和眼睛与涂料直接接触(如使用工作服,手套,护目镜,面罩及涂防护油等)。若皮肤不慎与产品相接触,请用清水及肥皂或适当的工业清洁剂彻底清洗；若眼睛受到污染,请即刻用清水冲洗至少 10 分钟,并立即就医。在施工时，建议佩戴面罩以免吸入漆雾和有害气体，尤其在通风不良的环境下，更要注意。最后请谨慎处理废旧漆桶以免污染环境。责任声明：对于未按本公司所要求采取有效得安全措施而引起的安全事故,本公司不负任何责任。来源 纽克莱涂料 http:/www.nsk-
